• 地址:济南市工业北路81号北邻
  • 电话:0531-88686388
  • 手机:13969159292
  • 网址:www.jnjgcg.com
新闻中心当前位置:首页-新闻中心
    彩钢板隔断墙施工工艺你了解多少?
    发布来源:http://www.jnjgcg.com/  2017-6-19 15:41:01 发布人:济南坚固彩钢
    彩钢板隔断墙施工工艺 你了解多少?下面我们就来详细介绍一下:彩钢板隔断墙施工工艺以及彩钢板隔墙的优点。彩钢板隔断墙施工工艺:
    Color steel plate partition wall construction technology, how much do you know? Below we come to detail: color steel plate partition wall construction technology and color steel partition wall advantages. Construction process of color steel plate partition wall:
    一、施工材料要求
    I. requirements for construction materials
    1、对工程所用的主要材料,成品,半成品是否符合设计规定,认真进行检验,有庇点材料一律不使用。
    1, the main materials used for the project, finished products, semi-finished products are in line with the design requirements, a serious inspection, there are shelter materials are not used.
    2、洁净室内不使用木质材料和其它不符合洁净标准要求的材料。
    2 clean rooms do not use wood materials and other materials that do not meet the requirements of clean standards.
    3、各种进场材料存放在有围护设施,清洁干燥的环境中,并平整地放置在防潮膜上。
    3. All incoming materials are stored in enclosure, clean and dry, and laid on moisture barrier.
    4、彩钢板与铝型材选用。
    4 、 color steel plate and aluminum profile selection.
    5、彩钢板采用上海宝钢生产的卷材,二度漆膜,色标为统一乳白色,无色差。

    5, color steel plate produced by Shanghai Baosteel, two degrees paint film, the color code for a unified white, no color difference.

    济南彩钢板

    6、洁净区隔墙所有阴阳角均采用整体圆弧铝合金件联结,隔墙与地面之间采用专用圆弧踢脚线,圆弧半径为R=50,
    6, the clean area partition wall, all the Yin and Yang angles are connected with the whole arc aluminum alloy parts, the wall and the ground between the use of dedicated arc skirting line, arc radius of R=50,
    7、彩钢板表面挺括,折弯处呈直线,模板尺寸无误差,彩钢发泡板不允许有整体拱,陷现象。
    7, color plate surface smooth, bending straight, template size error, Caigang foam board is not allowed to have the whole arch collapse phenomenon.
    8、所有门采用不锈钢纯化处理执手型门锁,锁芯距门沿大于65mm,凡可通往洁净区外的门锁有钥匙的锁芯外,其余不配有钥匙的锁芯。
    8, all stainless steel door handle purification type lock, lock the door from the door to more than 65mm, which can be outside the clean area with a key lock core, a lock core with a key in the rest of.
    二、施工具备的条件
    Two, the construction has the condition
    1、洁净区域的彩钢板安装,在土建及装饰工程完成后才施工,室内的空间做到清洁,无积尘。
    1, clean area of color steel plate installation, in civil engineering and decoration project after completion of construction, indoor space clean, no dust accumulation.
    2、对地坪平整度要求较高,个别原地不平整的地方,报业主由地面施工单位处理。
    2, the higher requirements for the flatness of the floor, where the individual is not in place, the newspaper owners are handled by the ground construction units.
    3、吊顶内的管线、风管施工结束后,须经过试压及隐蔽验收后才进行彩钢板施工。
    3, the ceiling of the pipeline, duct construction, after the test pressure and hidden acceptance before the Choi steel construction.
    彩钢板隔墙的优点:
    Advantages of color steel partition wall:
    1.外表美观,环保。
    1., beautiful appearance, environmental protection.
    2.价格实惠,使建造车间或改造车间成本降低。
    2., affordable, so that the construction workshop or transformation workshop cost reduction.
    3.色泽鲜艳:无须表面装饰,彩色镀锌钢板防腐层保持期在10-15年。
    3., bright colors: no surface decoration, color galvanized steel plate, corrosion protection period of 10-15 years.
    4.安装灵活快捷:施工周期可缩短40%以上.车间都会根据生产需要进行调整,使用彩钢板墙体,让车间改造施工方便。
    4., flexible and fast installation: construction cycle can be reduced by more than 40%. Workshop will be adjusted according to production needs, the use of color steel wall, so that the workshop transformation, construction convenience.
    5.重量轻:10-14千克/平方米,相当于砖墙的1/30 。
    5. light weight: 10-14 kg / m2, equivalent to 1/30 of brick wall.
    6.隔热保温:芯材导热系数: λ<=0.041w/mk。
    6. heat insulation: core material thermal conductivity: lambda <=0.041w/mk.
    7.强度高:可作天花围护结构板材承重,抗弯抗压;一般房屋不用梁柱。
    7., high strength: can be used for smallpox retaining structure, plate bearing, bending and compression; general houses do not beam column.
    我们竭诚欢迎各界人士精诚合作,我们将以更完善快速的方式赢得你的信赖。
    We sincerely welcome people from all walks of life to cooperate sincerely, and we will win your trust in the most perfect and quick way.