• 地址:济南市工业北路81号北邻
  • 电话:0531-88686388
  • 手机:13969159292
  • 网址:www.jnjgcg.com
新闻中心当前位置:首页-新闻中心
    彩钢瓦防腐喷涂的流程要注意什么?
    发布来源:http://www.jnjgcg.com/  2018-9-13 16:00:04 发布人:济南坚固彩钢
    1、首先采用水枪冲洗,然后角向磨光机、钢丝刷、铁砂布等工具将基面灰尘、污垢、毛刺、水渍、油脂和老化的漆层等附着物清洗干净。
    1. First use water gun to wash, then angle grinder, steel wire brush, iron abrasive cloth and other tools will be the base dust, dirt, burrs, water stains, grease and aging paint and other attachments clean.
    2、基面清理后经合格后可进行喷涂层施工。
    2. After the cleaning of the base surface, the spraying layer can be constructed after being qualified.
    3、为防止二次污染,在基面处理后立即喷涂一遍。
    3, in order to prevent the two pollution, spray it on the base surface immediately after processing.

    4、彩钢瓦喷涂施工前用毛刷或压缩空气格表面、阴角、沟槽的粉尘清除干净。

    济南彩钢瓦厂

    4. Clean the surface, shade angle and groove with brush or compressed air before spraying.
    5、按产品规定配比配制涂料,并搅拌均匀,熟化时间控制在30分钟,在6小时内施工完毕,涂装间隔不能小于24小时,不大于7天。
    5. Prepare the paint according to the prescribed proportion of the product, mix evenly, control the curing time in 30 minutes, finish the construction in 6 hours, the painting interval should not be less than 24 hours, not less than 7 days.
    6、施工温度在5度一35度,相对湿度85%,在有雨、雾、雪和较大灰尘条件下不可施工。
    6. The construction temperature is between 5 and 35 degrees, and the relative humidity is 85%. It can not be constructed under the condition of rain, fog, snow and large dust.
    7、施工所用工具应清洁干燥,涂料不得混有水分、香蕉水、醇类溶剂、汽油等及其它杂质,涂料现配现用,须在6小时内公司完毕,以防止结胶,造成不必要的损失,提高施工成本。
    7. The tools used in the construction should be clean and dry. The paint should not be mixed with water, banana water, alcohol solvents, gasoline and other impurities. The paint should be ready for use and be finished within 6 hours to prevent cementing, cause unnecessary losses and increase the construction cost.
    8、确认无漏除、无锈粉的情况下进行涂层施工。
    8. Confirm the coating construction without leakage and rust free.
    9、喷涂时应保持每遍涂层的厚度和涂层的总厚度。
    9. The thickness of the coating and the total thickness of the coating should be maintained during spraying.
    本文的精彩内容来自: 济南彩钢瓦厂更多的详细内容请点击我们的官方网站:http://www.jnjgcg.com谢谢您的到来
    The highlights of this article come from: Jinan Caigang Tile Factory for more details please click our official website: http://www.jnjgcg.com Thank you for coming